Concrete garage base disaster?

Firstly, thanks to those who offered advice on my recent queries regarding my new garage concrete base.

I now have a big problem and I'd be very grateful for advice.

A third of the slab has been laid, but it looks like I have a strip of about 2ft by 8ft at the far end of the slab (under which will be the end of the concrete sectional garage) which seems to have very low concrete to ballast ratio. So much so, that 24 hours after laying, I can break the surface with my thumb. I'm guessing that it's been mixed at about 6 to 1 ratio, opposed to the correct 3 to 1. A part of the slab that _does_ have the correct ratio, is rock hard.

How much of a problem might this be? Should I wait a further 24 hours and see if it firms up, or is it so obviously compromised that I should rip up the slab and start again.

I'd hate to build the garage and find that the poor concrete at the end starts falling away.

Anybody else here had a simialr predicament?

Advice, or even piss-taking, welcome.

Mal.

Reply to
Mal Jackson
Loading thread data ...

Even 6 to 1 should be fine. I'd wait a few days. Concrete doesn't always dry out evenly

Reply to
Stuart Noble

Concrete takes around 28 days to almost fully cure, and is usually very soft after a day, so much so that an ordinary brush will remove it at that stage. Just let it set.

NT

Reply to
meow2222

How level is this base ?

Sectional garages require a VERY level [ less than a cm/panel ideally] base if you are going to build the garage properly

Reply to
geoff

geoff wrote in news: snipped-for-privacy@virgin.net:

Hmm. another 24 hours later and it's a bit better.

I took a long time leveling the boarding around the base, and during laying of concrete, I used a cement finishing trowel to level the concrete with the boarding.

I should be easily within that tolerence.

Thanks all, for your replies.

Mal.

Reply to
Mal Jackson

HomeOwnersHub website is not affiliated with any of the manufacturers or service providers discussed here. All logos and trade names are the property of their respective owners.